Hydrotech Precision-PWS 8-M_8-MST OWNERS GUIDE Manual de usuario

PRECWater SystemsSION Precision Water Distillers Owners’ Guide Model: 8-M Model: 8-MST Par

10 Factors That Will Affect Your Water Distiller Production 1. Water Volume Measurement a) How are you measuring your water? The most accurate i

5. Heating Element and Boiler Cleanliness As the water distiller removes impurities some of the impurities may cling to the boiler tank and the heat

9. Boiling Tank Heating Element Once all other factors have been eliminated or checked, have an authorized service center check that the proper heat

Understanding How Pure Water is Produced Your water distiller operates the same as Nature’s hydrological cycle. See the Hydrological Cycle Diagram

Finding a Good Installation Location Before installing your water distiller it is important to find a good location. Following the points listed

Unpacking Your Water Distiller Your Water distiller has been shipped in one box. The Water Distiller Box Components Diagram shown as follows dis

(C) 1x(H) 1x(B) 1x(G) 1x (I) 4x(F) 1x(A) 1x (D) 1x (E) 4xWater Distiller Parts Bag Components Diagram Water Distiller Parts Bag Check List Check

COIL SUPPORT TIEWATER DISTILLER HEAD Shipping Tie Removal Diagram 4. Refer to Shipping Tie Removal Diagram above. Cut/Remove the coil support tie l

Water Distiller Leg Installation 1. Refer to the Water Distiller Leg Installation Diagram shown below. Place a ½ x 5/16” stainless steel washer o

2. Refer to the Sight Gauge Installation Diagram above. Remove the plastic hex jam nut from the threaded body of the valve (leaving water gasket on

This page left intentionally blank.2

Optional Storage Tank to Distiller Head Assembly 1. If you have purchased the optional storage tank, place the Charcoal Canister in the top of St

Impurities Drain Tube Installation 1. Refer to the Impurities Drain Tube Installation Diagram shown below. Remove the compression nut and compr

1. Remove any protective plastic coating (white, blue or clear plastic) from the lid. Boiling Tank Lid Installation Boiling Tank Lid Operation Di

Operation NOTE: Read all parts of the Owners Guide before operating the water distiller. Follow the Before Initial Water Distiller Operation ste

Power – ON/OFF - Red indicator light. - Normally ON when water distiller is operating. Controls power to the entire water distiller. - Top square

Before Initial Water Distiller Operation Perform steam sterilization on the water distiller head, filter canister and optional storage tank as desc

6. When the distiller has stopped, you may refill the boiling tank with water. Caution – The distiller will be very hot for several hours after shu

Maintenance and Cleaning Introduction The purpose of purchasing a water distiller is so you will not have to drink the unknown impurities in you

4. Check for scale build up on the walls of the boiler tank and the heating element. The heating element is the most critical. If there is 1/8” of

BOILER FLOATWATER GAUGEPININSIDE BOILERHEATINGELEMENTWATER LEVELIMPURITIES DRAINOUTLET Boiling Tank Water Gauge Pin Diagram 7. Let the solution stan

TABLE OF CONTENTS ...3 Ta

Replacing Charcoal in Post Charcoal Filter Canister (Used with 8-M without Optional Storage Tank) 1. Turn all switches off and allow the water di

Replacing Charcoal in Charcoal Filter Canister (Used with 8-MST Optional Storage Tank) 1. Turn all switches off and allow the water distiller to c

Sterilization Introduction: Steam Sterilization should be performed on the water distiller boiler and the optional storage tank before the water di

Steam Sterilization of Water Distiller Head 1. Make sure the water distiller is cool before starting. BULKHEAD,3/8"(INSIDE DISTILLER)STERILIZAT

distiller continues to heat up, it will sterilize the water distiller with steam by allowing pure steam to travel out of the cooling coil. Water and

Steam Sterilization of Water Distiller Head, Filter Canister and Optional Storage Tank 1. Make sure the water distiller is cool before starting. 2.

12.The water distiller head, filter canister and optional storage tank are sterilized and ready for operation. 36

Maintenance Schedule Table Initially Weekly Monthly Semi- AnnuallyAnnually As Needed1) Check Scale Build Up. X X 2) Change Charcoal in Charco

PROBLEM CAUSE A) Water distiller does not operate. 1. Water distiller is not plugged in securely to the wall outlet or the circuit breaker i

PROBLEM CAUSE D) Charcoal Filter is very hot and steam is escaping from the filter. 1. The fan switch is turned off. Check Switch. 2. Fan motor

Introduction Congratulations on the purchase of the most advanced water distiller in the industry! When installed and maintained properly, your Prec

Additional Options Water Distiller Cleaner and Descaler 600 g #500413 1600 g #500414 Used for regular maintenance to clean the scale out o

Specifications and Technical Information Model 8-M Electrical Specifications Voltage Amperage Power Frequency 120VAC 9.2 Amps 1100 Wat

Wiring List (8GPD Manual) Part # 500246-SERIES 15No. Part#ColorGaLengthFrom Conn. ToConn.From Location To Location1 500287GRN 16 3" #10RING#14-#

43 WIRING DIAGRAM, 8GPD MANUAL

Index Boiling Tank Lid, 22 Capacities distilled production, 41 storage tank, 41 Charcoal changing, 30, 31 Charcoal Filter Installing Canister, 31 Ch

Precision Water Systems Water Distiller Warranty Registration IMPORTANT! Precision Water Systems IMPORTANT! Thank you for purchasing

Records Please record all of the important information below to assist you and the service center in case there is any service work required in the f

Precision Water Systems Water Distiller Warranty - The warranty for your Precision Water Systems Water Distiller covers defects in materials for one

Important Safety Precautions When using electrical appliances, basic safety precautions should always be followed including the following: 1. Read a

Precision Water Systems Water Distiller Owners’ Summary The following is a summary of the information contained in this Owners’ Guide and required to

Water Distiller and Optional Storage Tank Features 8-M Distiller Features CONDENSING COIL SHIPPING STRAP(REMOVE BEFORE USE)FAN SWITCHPOWER SWITCHO